Previous in Forum: Compressor Choices   Next in Forum: Cut Shrinkage Not Allowed Machining
Close
Close
Close
2 comments
Rate Comments: Nested
Active Contributor

Join Date: Apr 2008
Location: Pasadena, CA
Posts: 11

Plate Natural Frequencies?

11/10/2009 8:03 PM

What is the natural frequency of an (A x B x t) plate, clamped on 3 sides?

Next: Simply-supported on 2 opposite sides and clamped on 1 other side?

Thanks! -Brian

Register to Reply
This discussion was "closed" on 11/11/2009 8:34 AM. No new comments are allowed.
Message from admins:
CR4 is not a homework cheat site.
Guru

Join Date: Aug 2007
Posts: 1790
Good Answers: 87
#1

Re: Plate Natural Frequencies?

11/11/2009 1:27 AM

Hmmm sounds a lot like homework.....

Register to Reply
Anonymous Poster
#2
In reply to #1

Re: Plate Natural Frequencies?

11/11/2009 3:26 AM

Did you resonate with that frequency ?

Register to Reply Off Topic (Score 5)
Register to Reply 2 comments
This discussion was "closed" on 11/11/2009 8:34 AM. No new comments are allowed.
Message from admins:
CR4 is not a homework cheat site.

Previous in Forum: Compressor Choices   Next in Forum: Cut Shrinkage Not Allowed Machining

Advertisement