Previous in Forum: Emergency Lights   Next in Forum: Cables vs. Bus Ducts
Close
Close
Close
2 comments
Rate Comments: Nested
Anonymous Poster

Selecting and Sizing Terminal Blocks

12/15/2009 2:32 PM

Dear ,

Ihave to make selection of terminal block ?

If i have a 150mm2 cable on each phase 2 sets so what could be the terminal block to be selected for this size?

Reply
Interested in this topic? By joining CR4 you can "subscribe" to
this discussion and receive notification when new comments are added.
Guru
United States - Member - New Member

Join Date: Jun 2008
Location: Alabama
Posts: 1604
Good Answers: 63
#1

Re: Selecting and Sizing Terminal Blocks

12/15/2009 6:09 PM

use Google or Bing and search for "terminal blocks for 150mm2 cable on each phase"

Lots of hits.

http://www.surplussales.com/Electrical/TerminalStrips/TermStrip-7.html

Reply
Guru

Join Date: Oct 2009
Posts: 2061
Good Answers: 169
#2

Re: Selecting and Sizing Terminal Blocks

12/18/2009 8:50 AM

If the cable is 150 sq.mm, I would rather have a bus bar link with a mounting hole and the two cable lugs will be placed one on either side of this link (front and back). But, ensure that the link is appropriately sized too.

Or else one can go for a suitbaly sized Stud-Type Terminal Block.

Reply
Reply to Forum Thread 2 comments

Previous in Forum: Emergency Lights   Next in Forum: Cables vs. Bus Ducts

Advertisement