Previous in Forum: Help a Newbie with Schematic Symbols ^_^"   Next in Forum: Pump Charger
Close
Close
Close
2 comments
Rate Comments: Nested
Active Contributor

Join Date: Jul 2009
Location: Malaysia
Posts: 10

Contact Insertion Sleeve

06/20/2011 11:06 PM

Dear all,

Attached below is a insertion sleeve in a electrical contact insertion sleeve( I'm not sure is this a correct name) for a electric contact post, picture shown is remove after used.

Anyone have any idea who will be able to supply me this contact sleeve.

Thanks,

Moi

Register to Reply
Interested in this topic? By joining CR4 you can "subscribe" to
this discussion and receive notification when new comments are added.
Guru
Australia - Member - New Member

Join Date: Feb 2008
Location: Australia
Posts: 2181
Good Answers: 255
#1

Re: Contact Insertion Sleeve

06/20/2011 11:10 PM

I suggest look to the manufacturer of the equipmentthat it is installed in.

Cannot pick the size from the picture, but in your part of the world, Sumitomo Wiring systems or Yazaki might be good organisations to start with (provided you are after 100k or more) They are probably not available as a one-off and you would need to purchase the whole contactor/connector.

__________________
Just an Engineer from the land down under.
Register to Reply
Active Contributor

Join Date: Jul 2009
Location: Malaysia
Posts: 10
#2
In reply to #1

Re: Contact Insertion Sleeve

06/20/2011 11:35 PM

the diameter of the sleeve is about 7.5mm.

Register to Reply
Register to Reply 2 comments

Previous in Forum: Help a Newbie with Schematic Symbols ^_^"   Next in Forum: Pump Charger

Advertisement