Previous in Forum: 2001 Chevy Cavalier Won't Start   Next in Forum: 1992 Jeep - Catalytic Converter
Close
Close
Close
Rate Comments: Nested
Commentator

Join Date: Jul 2007
Location: England
Posts: 67

Changing the Boot Badge on a 645ci 2004?

09/24/2009 2:58 PM

Has anyone tried changing the boot badge which acts as a boot opening button on the vehicle. The lacquer and paint is such rubbish it has worn off the emblem and looks tired so new one has arrived (two pins on the rear)but before I make a goof any tips? Thanks Martin

__________________
We can make a difference,e mail me and make it happen.
Register to Reply
Interested in this topic? By joining CR4 you can "subscribe" to
this discussion and receive notification when new comments are added.
Guru
Hobbies - RC Aircraft - New Member Hobbies - Automotive Performance - New Member Hobbies - DIY Welding - New Member

Join Date: Jul 2007
Location: Fort Lauderdale Florida
Posts: 5708
Good Answers: 123
#1

Re: Changing the Boot Badge on a 645ci 2004?

09/25/2009 10:07 AM

If it is the same as the us built BMWs the two pins are held by 2 plastic retainers that are pushed into the body. If you do not have new retainers, you should pick them up. It would really piss you off to have that new badge come lose ans chip the paint on the car. The method I have seen used is to take a roll of masking tape, and put about three layers right next to the badge in 4 spots. Then take a small flat bladed screwdriver and pry between the badge and the tape. VERY carefully. Good luck.

__________________
Bob
Register to Reply
Register to Reply

Previous in Forum: 2001 Chevy Cavalier Won't Start   Next in Forum: 1992 Jeep - Catalytic Converter

Advertisement